APC SMT 1000i UPS

APC SMT 1000i UPS. We recently upgraded our bench UPS to a APC SMT 1000i.  APC SMT 1000i UPS. The factory batterys were removed and we custom made a new set to replace. We used 4x Ritar 6v 8Ah in series and added a 6v 12Ah Yuasa battery in parallel to add a bit more […]

MAN TGX Adblue ECU Fault

MAN TGX Adblue ECU Fault. This ECU was sent to us by a national haulier. Fault was no power to the injector heater circuit.  MAN TGX Adblue ECU Fault. The ECU was tested and the MCU found to be internally shorted.  The best and most cost effective option in this case was to make a […]

Mitsubishi Pajero ECU Clone

MITSUBISHI PAJERO ECU CLONE. Water ingress had damaged this ECU beyond economical repair.  MITSUBISHI PAJERO ECU CLONE. A straight forward clone job. Nothing much more to say! 

TOYOTA AYGO CLUSTER INDICATOR LIGHTS NOT WORKING

TOYOTA AYGO CLUSTER INDICATOR LIGHTS NOT WORKING. This problem occurs in the Toyota Aygo, Citroen C1 and Peugeot 107 vehicles.  No tell tale indicator lights are illuminated on the cluster display. TOYOTA AYGO CLUSTER INDICATOR LIGHTS NOT WORKING. The usual problem of extremely poor quality solder, many heat cycles and vibration cause hairline cracks in […]

Camper Trolley 2500 Repair

Camper Trolley

CAMPER TROLLEY 2500 REPAIR. This Camper Mover was left out in the rain and suffered water ingress. CAMPER TROLLEY 2500 REPAIR. Damage due to water ingress was evident on the main RX PCB and motor driver PCB. Also, due to poor quality solder and no conformal coating, there was also damage to the transmitter PCB […]

VECTRA C SIMTEC 75.1 ECU CLONE

VECTRA C SIMTEC 75.1 ECU CLONE. We have not seen one of these in years. Customer complaint was vehicle parked up for many years, on starting there was a DTC stored to replace the ECU. VECTRA C SIMTEC 75.1 ECU CLONE. This probably could have been resolved by simply reflashing the firmware, but our customer […]

Fiat 500-Ford KA Continental SRS ECU No Comms

Fiat 500-Ford KA Continental SRS ECU No Comms. We have seen a few of these now where the fault is there is no communication with the SRS module, either when doing a scan over OBD connecting on the bench. Fiat 500-Ford KA Continental SRS ECU No Comms. This will result in many other phantom errors […]

Ford Transit 2015 ECU Clone SID208

Ford Transit 2015 ECU Clone SID208. Complaint was vehicle cranks but no start. Code P0341 was stored. FORD TRANSIT 2015 ECU CLONE SID208. Opening up the ECU on the bench, we began testing.  Using a signal generator on the cam sensor multipin, we injected a signal into the circuit.  It was found that all inline […]

Toyota Aygo MMT

TOYOTA AYGO MMT. The usual issue on these is the sync is lost for the gears. Either a flashing N on the dash, or no display at all. TOYOTA AYGO MMT. Great cars let down by a crappy designed gear selector system. Fault usually occurs when changing the clutch or selector solenoids. The ECU looses […]

FERRARI MONDIAL NON START

FERRARI MONDIAL NON START. This vehicle was in storage for a year. When the owner tried to start, there was no ignition. FERRARI MONDIAL NON START. After looking at our factory wiring diagrams (in Italian), we set about testing the ignition system from key, to ignition module and finally onto the coils.  All was good, […]

error: Content is protected !!