2010 Mercedes C Class EIS and Key Fault. We were asked by a garage to take a look at this C Class EIS problem. The key is not accepted in

Dodge Ram 5.7 ECU Clone. A reverse polarity event damaged this Motorola ECU beyond repair. We were asked to clone to another virgin ECU imported from the USA and to

FORD GALAXY CLUSTER PROBLEM. Yet another lovely Visteon cluster causing a non start situation. FORD GALAXY CLUSTER PROBLEM. Usual problem with these units is that cheap solder was used at

Mercedes E class SRS reset and clone. This unit was in a vehicle that had it’s battery connected the wrong way around. This corrupted parts of the flash and also

TOYOTA AYGO MMT. The usual issue on these is the sync is lost for the gears. Either a flashing N on the dash, or no display at all. TOYOTA AYGO

FIAT DUCATO FAULTY SRS ECU. ERROR B1001. Yet another TRW corrupt EEPROM! This problem occurs when there has been a low voltage event on the vehicle. Customer was advised that

Can Am Maverick Limp Mode. We were asked to take a look at this Can Am Maverick as after a while of driving, it would go into limp mode. Can

Jaguar X Type Cluster Clone. Not sure what the original fault was with this as this job was done for a remote customer and we had very limited information.  Jaguar

BMW Z3 SRS ECU REPAIR (MRS3). This job came to us after being looked at by several other companies. Complaint was module not seen on the network, SRS light illuminated.

VECTRA C SIMTEC 75.1 ECU CLONE. We have not seen one of these in years. Customer complaint was vehicle parked up for many years, on starting there was a DTC

MAN TGX Adblue ECU Fault. This ECU was sent to us by a national haulier. Fault was no power to the injector heater circuit.  MAN TGX Adblue ECU Fault. The

CAMPER TROLLEY 2500 REPAIR. This Camper Mover was left out in the rain and suffered water ingress. CAMPER TROLLEY 2500 REPAIR. Damage due to water ingress was evident on the

Fiat 500-Ford KA Continental SRS ECU No Comms. We have seen a few of these now where the fault is there is no communication with the SRS module, either when

Mercedes E320 CDi ECU Fault. We had a this Mercedes ECU sent to us over the pond from Texas. Customer stated vehicle no start and no diag.  Mercedes E320 CDi

APC SMT 1000i UPS. We recently upgraded our bench UPS to a APC SMT 1000i.  APC SMT 1000i UPS. The factory batterys were removed and we custom made a new

Haynes Motor Museum Mercedes W129 ECU Programming. This Mercedes W129 project turned out to be one of the more involved jobs we’ve taken on recently. The car arrived to us

Mitsubishi 3000GT Tour/Sport Suspension Problem. We had this Mitsubishi 3000GT Suspension ECU with the common Tour/Sport error.  It was given to us by a returning customer. Sometimes the error would

FERRARI MONDIAL NON START. This vehicle was in storage for a year. When the owner tried to start, there was no ignition. FERRARI MONDIAL NON START. After looking at our

HYUNDAI TERRACAN DDCR ECU CLONE. Not seen one of these for nearly 20 years! Vehicle suffered an injector malfunction which in turn shorted out various internal ECU components.  HYUNDAI TERRACAN

PSA group BSI issues. This vehicle was suffering from inoperative front windows, no info displayed on the MFD and central locking inoperative. PSA group BSI issues The usual poor French

Ford Powershift 6DCT450 Fault. This job came to us from CAN Diagnostic. This TCM is fitted to a range of Ford and Volvo vehicles. There was an issue with the pump

2016 Mercedes E Class ABS Fault. We were asked by a local automotive company to take a look at this ABS unit that suffered from intermittent comms on the CAN

BMW E88 KEY FOB CHANGE The key was unable to operate any remote locking functions, although it started the vehicle fine. BMW E88 KEY FOB CHANGE. These keys use a

Vehicle Programming Battery Maintainer. We decided to make our own battery maintainer that was on a par with BMW’s Deutronics £1300 tool. Vehicle Programming Battery Maintainer. When doing any software

Fiat 500 cluster problem. A typical fault on this vehile is where the indicator warning lights and/or other warning lights will stay dimly lit. The problem is at component level

1995 VW PASSAT IMMO REMOVAL. This job came to us after our customer lost all the keys to the vehicle. A locksmith was used to cut a new key, but

Porsche Boxster Alarm Unit 996.618.262.02 water damage and immobiliser problem Adding to the complexity, water ingress and attempts to start the vehicle with a low battery caused data corruption of

Suzuki GSXR-1000 LED Cluster Mod. We were asked if we could change the old filament bulbs to bright, modern LED’s on this motorbike cluster. Suzuki GSXR-1000 LED Cluster Mod. A

BMW 318 Missfire Continental MSD 81.2 ECU was bought to us with cylinder 2 missfire problem from a 2009 BMW 318i 2.0 petrol. Customer had changed the COP and finally

Another Vauxhall Corsa D Damaged ECU. Not the worst we have seen, but getting there! Was right on the edge of being beyond economical repair. Another Vauxhall Corsa D Damaged

Vauxhall Corsa D ECU Water Ingress. If we had a Pound for every one of these that we have repaired, we would have our own Carribean island by now. Vauxhall

MG ZR Keyfob Buton. Customer complaint was vehicle did not lock or unlock even when the fob battery was replaced. MG ZR Keyfob Button. First thing was to assertain if

MITSUBISHI PAJERO ECU CLONE. Water ingress had damaged this ECU beyond economical repair.  MITSUBISHI PAJERO ECU CLONE. A straight forward clone job. Nothing much more to say! 

Kia C’eed Corrupt SRS ECU. A company asked us to take a look at this SRS ECU. Symptoms were able to get comms with the unit on the vehicle, but

TOYOTA AYGO CLUSTER INDICATOR LIGHTS NOT WORKING. This problem occurs in the Toyota Aygo, Citroen C1 and Peugeot 107 vehicles.  No tell tale indicator lights are illuminated on the cluster

2013 Ford KA SRS Crash Delete. We were asked by a local garage to remove the crash data from the airbag ECU after a small bump into a bollard in

Ford Ranger No Dipped Beam. We have done many of these over the years. Typical symptoms are no dipped and/or high beam headlights either in entirety or on one side.

VW GOLF MK1 CLUSTER REPAIR. Complaint was odometer and trip not working, along with a non functioning lcd clock. VW GOLF MK1 CLUSTER REPAIR. We disassembled the cluster and found

TRW SRS B1001 ECU error. Another one of these TRW SRS B1001 ECU error jobs. We get several each week sent to us from all over the world. There is

Corsa D Faulty ECU. Every now and again, a job comes in where its so hard to believe how the hell has this happened. This is one such case from

Ford Transit 2015 ECU Clone SID208. Complaint was vehicle cranks but no start. Code P0341 was stored. FORD TRANSIT 2015 ECU CLONE SID208. Opening up the ECU on the bench,

VW Golf MK6 Tune. We have always worked closely with L&M Auto Repairs. He has a big Youtube channel that you can check out by clicking HERE You can also join

Vauxhall Frontera 2.2DTi ECU Clone. A reverse polarity event rendered this vintage ECU beyond repair. We were tasked to clone and to source another secondhand ECU. Vauxhall Frontera 2.2 DTi

Smart Car SAM Clone. Water ingress had caused damage to our customers SAM. It was more economical to source a replacement and clone. Smart Car SAM Clone. Really easy job

Ford Mondeo ECU Tune . We were asked to tune this Mondeo’s ECU for more mid range torque. Ford Mondeo ECU Tune. Nothing much to report here, a nice easy

Kids Electric Car. We were asked to have a look at this kids ride on Porsche. It was left out in the rain and no longer worked. Kids Electric Car.

FORD FOCUS ST CLUSTER PROBLEM. Another lovely Visteon cluster causing a non start situation. FORD FOCUS ST CLUSTER PROBLEM. Usual problem with these units is that cheap solder was used

Porsche Boxer Alarm Unit 996.618.262.02 We have done quite a few of these jobs over the years. Due to the location of the module they suffer from water ingress. It

2012 Ford Focus Faulty Cluster. Quite a common issue with these Visteon clusters is that they cause a no start situation, randomly cutting out and/or erratic gauge readings. 2012 Ford

2017 Range Rover Sport ECU Tune. We were asked by the owner of a local garage if we could tune his Range Rover Sport. As he uses the vehicle for

BMW F30 Damaged ECU.  Water ingress into the fuse/ECU housing from the scuttle panel of this 5 year old vehicle, completely destroyed the ECU! BMW F30 Damaged ECU Many MOSFETS

Launch X-431 V+ PRO Diagnostic Tool. We only use dealer tools for all of our jobs, however setting up these tools can be a long winded, time consuming process. We

VW TOURAN DPF SW REMOVAL AND TUNE. Siemens PPD1, multiple DPF related errors, temperature and pressure, soot content was only 45%. VW TOURAN DPF SW REMOVAL AND TUNE. Another vehicle